Chapin 22790 User Manual download pdf

WARNING!

Printed in U.S.A.

3. Pre-Use Check

4. Filling

1) Do: Turn pump handle counterclockwise and remove pump

2) Do: Prepare spray solution following all directions and safety warnings on

chemical label.

3) Do: Fill tank to no more than the proper gallon marker. Do NOT: over ﬁll to

accommodate pump.

4) Do: Check pump to make sure that no grass or dirt is stuck to barrel. Replace pump in

tank and tighten securely.

5. Pressurizing and Spraying

Do: Turn handle clockwise to tighten.

Push handle down, turn 1/4 turn

counterclockwise to release.

Do: Pump until you

feel resistance.

Do: Push handle, down, turn 1/4 turn clockwise to

lock. Begin spraying. Re-pump sprayer as required

to maintain spray force.

7. To Release Pressure

1) Your sprayer is equipped with a pressure relief/release valve.

To release pressure lift and hold the cap until air is completely

exhausted, OR, turn the valve slowly counterclockwise until

you hear air escaping and wait air is completely exhausted.

2) Do: Stay away from the sprayer until all air has escaped.

8. Care, Storage and Maintenance

1) Do: Rinse tank thoroughly with water only, empty, reﬁll with water. Follow Filling, Pres-

surizing and Spraying Instructions, except pump unit only 8-10 strokes.

2) Do: Open shut-oﬀ and allow water to run through discharge assembly.

3) Do: Release pressure (Follow Pressure Release Instructions), remove pump and empty

sprayer.

4) Do: Store sprayer tank upside down, with pump removed, in a warm dry location.

5) Do: Periodically oil pump by dropping 10-12 drops of light oil down pump rod through

opening in cover.

010538-3 (A) R0909

1. Hose to Tank

WARNING: Handling the

brass parts of this product

will expose you to lead, a

chemical known to the State

of California to cause birth

defects and other reproduc-

tive harm. Wash hands after

handling.

2. Nozzle

Hazard: Improper use or failure to follow instructions can result in explosive failure

causing serious eye or other injury. For safe use of this product you must read and follow

all instructions. Do not leave a pressurized sprayer in the hot sun. Heat can cause pressure

build-up. Do not store or leave solution in tank after use. Always wear goggles, gloves, long

sleeve shirt, long pants and full foot protection when spraying. Never use any tool to remove

pump if there is pressure in sprayer. Never stand with face or body over top of tank when

pumping or loosening pump to prevent ejecting pump assembly and/or solution from strik-

ing and injuring you. Never pressurize sprayer by any means other than the original pump.

Do not attempt to modify or repair this product except with original manufacturer’s parts.

Never spray ﬂammable materials or heat, pressure, or gas producing chemicals. Always

read and follow manufacturer’s instructions before use with this sprayer as some chemi-

cals may be hazardous when used with this sprayer.

Sk-1113-1

For constant spraying, push down on shut-oﬀ

handle and move locking mechanism away from

you. To release, squeeze handle and move the

locking mechanism back towards you.

6. Fatigue-Free Spraying

Note: Your particular sprayer may not include all parts pictured above.

Nota: Es posible que este pulverizador en particular no incluya todas las partes que se ilustran arriba.

Remarque : Votre pulvérisateur particulier pourrait ne pas inclure toutes les pièces illustrées plus haut.

Attach nozzle to extension wand (22790).

6-1898

Shut-oﬀ Handle

Mango de cierre

Poignée du robinet

Parts, Piezas, Pièces

6-6141

Hose Brown

Manguera Castaño

Tuyau Brun

6-7711

Extension wand, Vara de extensión, Rallonge (22180,

22170)

1-5941

Nozzle .5GPM

Tobera

Buse

Turn clockwise to tighten hose clamp.

Repair Parts Kit Gaskets and Seals (not included),

Juego de piezas de reparación, empaquetaduras y juntas (no incluido)

Kit de pièces de réparation, joints et garniture d’étanchéité (non inclus) 6-5368

6-3337

Straps

Tirantes

Sangles

6-7742

Extension wand, Vara de extensión, Rallonge (22790)

1-5797

Nozzle .5GPM

Tobera

Buse

22790

22180

22170

Attach nozzle to shut-oﬀ handle or extension wand (22180, 22170).

1) Do: Check tightness of hose clamp to be sure hose is securely attached to the tank outlet.

2) Do: Inspect hose for deterioration, cracks, softness, or brittleness. If any of these

conditions are found, replace hose before using. Replace with original manufacturer’s

parts only.

3) Do: Remove pump (see Filling, Pressurizing and Spraying Instructions), inspect interior

and exterior of tank for signs of deterioration of body and bottom. Any sign of

deterioration indicates possible tank weakening and could result in explosive bursting

under pressure. If any of these signs are found, discard tank immediately and replace.

Do not attempt to patch leaks, etc., as this could result in serious injury.

4) Do: Follow Filling, Pressurizing and Spraying Instructions, except use water only.

5) Do: Pump plunger 8-10 strokes and inspect for leaks.

6) Do: Direct shut-oﬀ away from you and open to make sure discharge is not clogged.

7) Do: If unit passes this test, release pressure (see Pressure Releasing Instructions),

empty tank, and proceed with Filling, Pressurizing and Spraying Instructions.

1 2

Summary of Contents

Page 1 - WARNING!

WARNING!Printed in U.S.A.3. Pre-Use Check4. Filling1) Do: Turn pump handle counterclockwise and remove pump2) Do: Prepare spray solution following all

Page 2 - ADAVERTISSEMENT!

010538-3 (B) R09091) Sí: Veriﬁque el ajuste de la abrazadera de la manguera para asegurarse de que la manguera esté unida correctamente a la salida

Comments to this Manuals

No comments

Chapin 22790 User Manual

Browse online or download User Manual for Equipment Chapin 22790. Chapin 22790 User Manual

Summary of Contents

Comments to this Manuals